Acid Neutralizer
- Part number
- RXSOL-68-6803-030
- Category
- Metal Treatment
- Brand
- RXSOL
Overview
Acid Neutraliser is a alkaline solution for the neutralisation of acidic solution and waste. It contains an in built pH indicator to provide a visual colour change when neutralisation of spent acidic waste has been completed.
Technical specifications
| Appearance | dark pink alkaline liquid; mixes with water |
|---|---|
| pH | 12.0 ± 0.5 |
| Specific gravity | 1.14 - 1.1 |
| Solubility in water | miscible |
Applications
Acid Neutraliser allows users of pickling paste and other acidic metal treatment products to comply with pH requirements of trade waste water regulating authorities.
Dosage and directions
DIRECTIONS FOR USE
1) Neutralisation of retained acidic waste For every litre of spent Acidic waste, add approximately 1.7 litres of Acid Neutralizer. The Acid Neutralizer on contact with the spent acid waste will go clear. Keep on adding Pickling Paste Neutraliser solution till a faint pink coloration exist.
If neutralisation has not occurred with the initial dosage, then add additional quantities of Acid Neutraliser at 100ml per litre of waste until colour change is observed.
2) Diagnostic Use After washing the Acidic material and while still wet, spray the Acid Neutraliser solution directly onto the area where the pickling gel was applied, in particular in corners and crevices. If residual acid is present an effervescent reaction will occur. Flush with water thoroughly once the effervescence has stopped.
Avoid contact with skin or eyes.
Characteristics and notes
SAFETY PRECAUTIONS
Acid Neutraliser is an alkaline solution so that contact with skin and eyes is avoided. Wear eye goggles and appropriate protective clothing. If the product comes in contact with the skin immediately wash affected area thoroughly with water and soap. Seek medical attention in the event of irritation. If required remove and rinse contaminated clothing.
If the product comes in contact with the eyes, immediately hold the eyes open and wash with fresh running water. Ensure irrigation under the eye lids by occasionally lifting upper and lower lids. If pain persists or recurs, seek medical attention.
PACKAGING
Acid Neutraliser is packed in 2 Ltrs, 5 Ltrs, 20 litres, 25 Ltrs & 210 litres.
Safety and SDS
Read the safety data sheet before handling. Wear suitable gloves and eye protection.
View safety data sheet
| Product Name | : |
RXSOL-68-6803-030 |
| Product Type | : | Acid Neutralizer |
Company Details:
RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA
Stock Point : Mumbai, Kandla, Kolkata, Chennai, Visakhapatnam, Fujairah
| Phone | : | +91 22 27815541 / 42 |
| Fax | : | +91 22 2781 1318 :::AOH :0091 9821214367 |
| : | rxsolchemicals@gmail.com |
|
Chemical Name |
Concentration |
CAS Number |
EC Number |
R Phrases* |
Symbols |
|
Metalic hydroxide which includes Sodium Hydroxide |
27 - 36 |
1310-73-2 |
215-185-5 |
35 |
C |
|
Non classified ingredients |
64-73 |
These products are not classified as hazardous and lower then hazard limits |
NA |
NA |
NA |
*See Section 16
Corrosive
|
Odour |
Odourless. |
|
Appearance |
Liquid, colourless to yellow, soluble in water. |
|
Contact with eyes |
Corrosive to eyes Can cause damage to the eyes. |
|
Contact with skin |
Causes severe burns (R35). |
|
Inhalation |
No information available but must be considered harmful. |
|
Ingestion |
Harmful if swallowed (R22). |
|
Contact with skin |
Remove contaminated clothing immediately and drench affected skin with plenty of water Then wash with soap and water.Seek medical advice if necessary |
|
Contact with eyes |
If the substance has got into eyes, immediately wash out with plenty of water for at least 15 minutes. Irrigate eyes thoroughly whilst lifting eyelids.Obtain immediate medical attention. Continue flushing with water until medical help arrives |
|
Ingestion |
Do not induce vomiting.Never give anything by mouth to an unconscious person.Give water or milk to drink.Obtain immediate medical attention. |
|
General |
In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45) -When in doubt or symptoms persist, seek medical attention |
- Non-combustible
- Smoke from fires is corrosive
- Not flammable. In case of fire use extinguishing media appropriate to surrounding conditions
- Vapour density - not applicable
|
Personal Precautions |
Wear protective clothing as per section 8. |
|
Environmental Precautions |
Do not flush spilt material into any public water system. |
|
Clean Up Actions |
Absorb spillage in inert material and shovel up.Ventilate the area and wash spill site after material pickup is complete.Neutralise with Acid. |
|
Special Precautions |
Wear protective clothing as per section 8. |
|
Handling |
Eyewash bottles should be available.See Section 8 |
|
Storage |
Keep only in the original container in a cool, well-ventilated place (S3/9/49).Protect from frost. |
|
Exposure Limits |
OES / LTEL # ppm 2 mg/m3.(Sodium hydroxide) |
|
Exposure controls |
No special ventilation is required unless the product is used in a spray form |
|
Occupational exposure controls |
Wear suitable protective clothing, including eye/face protection and gloves (plastic or rubber are recommended).During fumigation/spraying wear suitable respiratory equipment (S42) |
Gloves Suit Goggles No_Smoking
|
Odour |
Odourless |
|
Appearance |
Liquid, colourless to yellow, soluble in water |
|
PH |
11.5 - 12.5 at 0.1 % concentration , Neat : 14.0 |
|
Boiling point |
100 °C at 760 mm /Hg |
|
Vapour pressure |
Not known |
|
Vapour density |
Not applicable |
|
Freezing point |
0 °C at 760 mm/Hg |
|
Completely soluble in water |
|
|
Specific gravity |
(water=1) 1.50 |
|
Non-combustible |
|
- This article is considered stable under normal conditions
- Avoid overheating, Keep away from frost
- Incompatible with acid
- See Section 5
|
Toxicological information |
The ingestion of significant quantities may cause burning sensation.Can cause damage to the digestive system. |
|
Inhalation |
Not regarded as a potential route of exposure. Can cause damage to the respiratory system. |
|
Contact with skin |
Causes severe burns (R35) |
|
Contact with eyes |
Causes severe burns (R35) |
|
Ingestion |
The ingestion of significant quantities may cause damage to the digestive system. |
|
Carcinogenicity |
No evidence of carcinogenic effects. |
|
Ecotoxicity |
May cause acute effects in the aquatic environment. |
|
Mobility |
Completely soluble in water. |
|
Persistence and Biodegradability |
Degrades by hydrolysis |
|
Bioaccumulation Potential |
Bioaccumulation is insignificant |
|
Other Adverse Effects |
No environmental problems are expected when the product is used/handled correctly. In its intended use, the product will not be released into the environment. |
|
Classification |
This material and/or its container must be disposed of as hazardous waste.EU Waste class: 06 02 02 |
|
Disposal considerations |
Do not discharge into drains or the environment, dispose to an authorised waste collection point.Disposal should be in accordance with local, state or national legislation |
| Proper Shipping Name: | ||||
| UN | ||||
| Proper Shipping Name | Sodium hydroxide. solution | |||
| UN NO. | 1824 | |||
| Hazard Class | 8 | Packing Group | II | |
| Road/Rail (ADR/RID) | ||||
| Proper Shipping Name | Sodium hydroxide. solution | |||
| ADR UN No. | 1824 | |||
| ADR Hazard Class | 8 | Termcard | 80S1824 | |
| Sear (IMDG) | ||||
| Proper Shipping Name | Sodium hydroxide. solution | |||
| IMDG UN No. | 1824 | |||
| IMDG Hazard Class | 8 | IMDG Pack Group | II | |
| IMDG EmS | F-A, S-B | IMDG subrisk | NA | |
|
Air(ICAO/IATA) |
||||
| ProperShippingName: |
Sodiumhydroxide, solution |
|||
| ICAO UnNo.: | 1824 | |||
| ICAO HazardClass.: | 8 | ICAO PackingGroup.: | II | |
| ICAO subrisk: |
N/A |
ICAO Labels | 8, CAO | |
| ICAO Flashpoint: |
N/A |
|||
| DOT/CFR(USDepartment ofTransportation | ||||
| DOTProperShippingName: | Sodium hydroxide, solution | |||
| hazardous material | Sodium hydroxide | |||
| Hazard Class: | 8 | IdentificationNumber: | UN1824 | |
| Product RQ (lbs): | 3640 | DOTsubrisk: |
N/A |
|
| DOTLabels: | 8 | DOTFlashpoint: | N/A | |
|
Risk Phrases |
Causes severe burns (R35) |
|
Safety Phrases |
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice (S26).Wear suitable protective clothing, eye/face protection (S36/39).In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45) |
The text of R and S phrase codes used in this safety data sheet:- R35: Causes severe burns.The information provided about the product on this Safety Data Sheet has been compiled from knowledge of the individual constituents The data given here is based on current knowledge and experience. This Safety Data Sheet describes the product in terms of safety requirements and does not signify any warranty with regard to the product's properties.The data given here only applies when product used for proper application(s). The product is not sold as suitable for other applications - usage in such may cause risks not mentioned in this sheet. Do not use for other application(s) without seeking advice from manufacture This Safety Data Sheet is provided in compliance with The Dangerous Substances Directive (67/548/EEC) This Safety Data Sheet is provided in compliance with The Dangerous Preparations Directive (88/379/EEC) This Safety Data Sheet is provided in compliance with The Safety Data Sheets Directive (2001/58EC)
DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.
Availability
Acid Neutralizer manufacturer and supplier in Mumbai, Kandla, Kolkata, Chennai, Visakhapatnam, Fujairah, Dubai, Abudhabi, Oman, Bahrain.
