Redkleen RX 400 Radiator Flush Cleaner
- Part number
- RXSOL-40-4051-025
- Category
- Radiator and AC coil cleaner
- Brand
- RXSOL
Overview
Redkleen RX 400 ( Radiator Flush & Clean) is a non-acidic radiator and cooling system cleaner that effectively cleans in one simple 20-minute operation. Many similar products have to be left in the cooling system for several days, which creates the risk of the user either forgetting or extending the drain and flush time for reasons of convenience. The results can be detrimental and cause expensive, long-term damage to the cooling system and associated components.Redkleen RX 400 ( Radiator Flush & Clean) overcomes this potential risk as the whole cleaning process is completed in one simple operation.
Technical specifications
Physical Properties and Tecnical Specification
| Appreance | : | Liquid |
| Colour | : | Clear, Brown |
| Odour | : | Odourless |
| pH | : | Alkaline 9-12.5 |
| Flash point | : | Not flamable |
| Boiling Point | 109 °C | |
| Freezing point | NA | |
| Solubility in Water |
Soluble in any ratio |
Applications
Use Redkleen RX 400 ( Radiator Flush & Clean) as a complete cooling system flush to remove insulating built-up sludge and residue before changing coolant in any cooling system. This procedure will ensure optimum heat transfer and efficiency of the entire cooling system. Whenever draining a cooling system or changing brands of coolant it is always recommended to clean the system with Redkleen RX 400.
Use Redkleen RX 400 before removing a radiator from a vehicle for reconditioning. Clean the entire system with Redkleen RX 400 so when the radiator is reinstalled, the core will not be contaminated with scale and residue from the rest of the system.
Dosage and directions
Directions for use
Note: Exercise caution when removing radiator caps. Release pressure slowly to avoid scalding.
- Turn on the heater and add required amount of RX 400 to a warm radiator.
- Run the engine for 20 minutes minimum (no longer than 1 hour). Stop the engine and allow it to cool.
- Drain the system by removing the bottom radiator hose or opening the drain cock. Thoroughly flush and rinse out all old coolant. Replace the hose or close the drain cock.
- Add RXSOL 4001 corrosion inhibitor and clean, soft or demineralised water, or
- Where specified, use anti-freeze/anti-boil coolant (such as RXSOL-4004 ultra Coolant).
-
Start the engine, check for leaks and top up as necessary.
Dose Rates
- All cars and light commercials - add 500 ml
- For trucks, tractors and large engines - add 500 ml for every 6 litres (quarts) of cooling system capacity.
Characteristics and notes
Features & Benefits :
- Cleans fast in 20 minutes
- Reduces overheating
- Safe to use with all coolant types
- No pre-mixing
- Neutralises harmful acids
- Reduces mineral scale and sludge
- Liquid easy to use and handle.
Packing : 1, 4, 20 25 Ltrs, 210 Ltrs.
Storage and Handling :
Keep container dry. In case of insufficient ventilation, wear suitable respiratory equipment. If you feel unwell, seek medical attention and show the label when possible. Avoid contact with skin and eyes. Keep away from incompatibles such as metals, acids.
Storage: Keep container tightly closed. Keep container in a cool, well-ventilated area.
Safety and SDS
Read the safety data sheet before handling. Wear suitable gloves and eye protection.
View safety data sheet
| Product Name | RXSOL-40-4051-025 |
| Trade Name | Redkleen RX 400 Radiator Flush & Cleaner |
Company Details:
RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA
Stock Point : Mumbai, Kandla, Kolkata, Chennai, Vizag, Gandhidham, Fujairah, Muscat, Nairobi
| Phone | +91 22 27815540 / 41 / 42 |
| Fax | +91 22 2781 1318 :::AOH :0091 9821214367 |
| rxsolchemicals@gmail.com |
Proprietory Blend Of Alkaline Surfactant ingredient.
POTENTIAL HEALTH EFFECTS:
| INHALATION: | Inhalation of vapor or mist is corrosive to respiratory tract. Symptoms include coughing, wheezing, laryngitis, shortness of breath, headache, nausea, and vomiting. |
| EYE CONTACT | Liquid , irritating to eyes. Immediate irritation followed by destruction of tissue |
| SKIN CONTACT | Use gloves. Dont directly on naked skin |
| INGESTION: | moderately toxic, causes nausea, vomiting, loss of consciousness |
| CHRONIC Effects | Damage to kidneys and liver .Changes in bones or joints |
| INHALATION: | Ensure the victim’s clothing or skin has not been contaminated by the acid before removing the victim to fresh air. If breathing has stopped, begin artificial respiration. Call ambulance immediately for assistance |
| EYE CONTACT: | Flush eyes with water for 15 minutes with copious cool flowing water. If only one eye is affected, be careful not to flush contaminated water into the other eye. Tilt the head in the direction of the affected eye while flushing. Take the victim to a medical facility immediately, and apply ice water compress during transport. |
| SKIN CONTACT: |
Move the victim immediately under an emergency shower or other water source and flush the affected area with large amounts of cool running water. Immediately washing off the acid is of primary importance. Remove all contaminated clothing while flushing with water. If there is a large area of exposure, arrange for emergency medical assistance while the victim is being rinsed with water.Immediately after flushing with water, begin massaging calcium gluconate gel into the burn site. Apply the gel every 15 minutes and massage until pain/redness resolves or until medical care is available. The first aider should wear gloves when applying the gel to prevent transfer of the acid. |
| INGESTION: | Do not induce vomiting. Rinse mouth out with water. Call an ambulance immediately for assistance |
| FLASHPOINT (TEST METHOD): | None |
| FLAMMABLE LIMITS: | |
| LOWER: | NA |
| UPPER: | NA |
| GENERAL HAZARD: | NA |
| FIRE FIGHTING INSTRUCTIONS: . | Approach fire from upwind side. Avoid breathing smoke, fumes, mist, or vapors on the downwind side.Firefighters wear protective clothing and self-contained breathing apparatus |
| EXTINGUISHING MEDIA: | Dry powder, carbon dioxide (CO2), water fog or spray |
| HAZARDOUS COMBUSTION PRODUCTS: . | Smoke, irritating vapors, toxic fumes of POx, and corrosive F fumes, CO, CO2 |
LAND SPILL: Emergency response coordinator must have mandated training. Eliminate all ignition sources.
SMALL SPILLS: Pick up with absorbent materials and place in non-leaking containers; seal tightly for proper disposal or reuse.
LARGE SPILLS: Evacuate the hazard area of unprotected personnel. Wear appropriate respirator and protective clothing. Shut off source of leak if safe to do so.
Dike and contain. Remove with vacuum trucks or pump to storage/salvage vessels.
WATER SPILL: Notify proper authorities.
Clean up leaks/spills immediately to prevent soil or water contamination.
HANDLING: Avoid contact with skin, eyes, and clothing. After handling this product, wash hands before eating, drinking or smoking. If contact
occurs, remove contaminated clothing. If needed, take first aid action shown in section IV. Launder contaminated clothing before reuse.
STORAGE: Store away from food stuffs, alkaline materials
PERSONAL PROTECTION: If TLV is exceeded wear NIOSH approved respirator. Use heavy rubber type gloves, full-face shield and boots,
aprons, drench showers, eye wash as needed for protection against spills and/or splashes
| Appreance | : | Liquid |
| Colour | : | Clear, Brown |
| Odour | : | Odourless |
| pH | : | Alkaline 9-12.5 |
| Flash point | : | Not flamable |
| Boiling Point | 109 °C | |
| Freezing point | NA | |
| Solubility in Water |
Soluble in any ratio |
| STABILITY: | Stable |
| CONDITIONS TO AVOID: | High temperatures |
| MATERIALS TO AVOID: | Acidic materials may react with metals to produce gas. |
| HAZARDOUS DECOMPOSITION PRODUCTS: | Corrosive F fumes, toxic POx fumes, from combustion -smoke, CO, CO2 |
| HAZARDOUS POLYMERIZATION: | Will not occur |
Phospho LDLo: 220 mg/kg (unr - man)
LD50: 1530 mg/kg (oral - rat)
LD50: 2740 mg/kg (skin - rat)
HF LCLo: 50 ppm / 30 M (inh - human)
LC50: 966 ppm / 1 hr (inh - rat)
TCLo: 100 mg/m3 (inh - human) NOSE,EYE, PUL
Harmful to aquatic life in high concentrations
Phospho 138 ppm / 24 hr / mosquito fish / TLm / fresh water
HF 60 ppm / fish / lethal / fresh water
Dispose as hazardous waste. Classification and documentation is required before disposal. Follow all local, state and federal regulations
Transport of dangerous goods by road , rail and inland waterway (ADR/RID/ADN)
| UN Number | None |
| Proper shipping name | Redkleen RX 400 Radiator Flush & Cleaner |
| Particulars in the transport document | Unrestricted, Not Classified as Dangerous Goods |
| Class | None |
| Packing group | None |
International Maritime Dangerous Goods Code (IMDG)
| UN Number | None |
| Proper shipping name | Redkleen RX 400 Radiator Flush & Cleaner |
| Particulars in the transport document | Unrestricted, Not Classified as Dangerous Goods |
| Class | None |
| Packing group | None |
International Civil Aviation Organization (ICAO-IATA/DGR)
| UN Number | None |
| Proper shipping name | Redkleen RX 400 Radiator Flush & Cleaner |
| Particulars in the transport document | Unrestricted, Not Classified as Dangerous Goods |
| Class | None |
| Packing group | None |
TSCA (Toxic Substance Control Act): Components of this product are listed on the TSCA Inventory.
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act): Silcate
Contact local authorities for other reporting requirements.
CALIFORNIA PROPOSITION 65: Not listed.
State Right-to-Know Programs: MA, NJ, PA
NFPA Ratings
Health: 4
Flammability: 0
Reactivity: 1
HMIS Protective Equipment: X See your supervisor.
| Other Information |
The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, express or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigations to determine the suitability of the information for their particular purposes. In no event shall be liable for any claims, losses, or damages of any third party or for lost profits or any special, indirect, incidental, consequential or exemplary damages, howsoever arising, even if RX Marine International has been advised of the possibility of such damages. DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable. |
Availability
Redkleen RX 400 Radiator Flush & Cleaner Manufacturer and supplier in Mumbai, Surat HAZIRA, Gandhidham Kandla Gujrat, Chennai, Visakhapatnam, Kolkata, Paradip, Sudan, Nairobi, Kenya, Muscat, Barka, Ruwi, Oman, Fujairah, Ajman, Abudhabi, Dubai, Sharjah, UAE Gulf, Yemen
