Multi Clean TANK WASH
- Part number
- RXSOL-16-1502-210
- Category
- Tank Cleaner
- Brand
- RXSOL
Overview
Multiclean supplier and Exporter. Multi clean is a specified tank cleaner which has mild alkaline emulsifier cleaning property.
Technical specifications
| PHASE | Liquid Pale Yellow |
|---|---|
| Specific Gravity @ 250C | 1.1 |
| pH ( 1% solution) | 11.5 Alkaline |
| Flash point | Non-flammable |
| Boilling Point | 100 Degree C |
| Solubility in Water | Completely Soluble in Water |
| Shelf Life & Storage | years at 20 C to 35 degree C. Store in cool, dry place |
Applications
Use at a concentration of 2% to 5%. Add 20 ml. RXSOL-16-1502-210 to 1 litre of hand-hot water. for SPOT CLEANING purpose.
Use 1.5% solution of RXSOL-16-1502-210 in a bucket of water. for general cleaning . No rinsing needed.
Use a 1% solution of RXSOL-16-1502-210 for SPRAY CLEANING
Use 0.2% solution of RXSOL-16-1502-210 For general cleaning where HOT cleaning required
Multi clean used as a tank cleaner degreaser and also common for ship hold cleaning.
Dosage and directions
Using-Procedure:-
First of all flush the system with cold water to prevent evaporation rates and polymerization then the most economical method is by direct injection followed by recirculation washing, using tank cleaning machines.
Spraying Method:- Spray onto areas where residue remains following rough washing leave for 10-45 minutes (but do not allow to dry), then butterworth at maximum pressure and warm water 60oC for at least 3 hours, checking that there is no foam remaining in the final stages. Inspects tanks(s) and if desired result has been achieved fresh water rinse and dry.
**Make sure to take all safety precautions are followed when handling / spraying as other GENERAL TANK CLEANER **
Injection Method:- Not applicable.
Re- Circulation Method:- Fill tank with fresh water and heat up to warm 50oC . IF a drop line is available on the tank line system, then start to circulate the water and add the required amount of Caustic flakes and MULT CLEAN to make a 2.5% solution. A stronger solution can be made, but be advised that too much Caustic and too high temperature will result in white powder all over the tank. Under normal circumstances, between 2.5% and 4.5% will be sufficient strength. If there is no drop line, then lower butterworth hoses into the tank from the pump stack header without machines attached and circulate through these hoses while you fill the solution material.
**Use a strainer at the pump stack when circulating any solution.** Tank Lining– Stainless / Epoxy / Phenolic.
Characteristics and notes
This product provides single product simplicity with multi cleaning application flexibility. This formulation provides this unique combination of deep cleaning and odor control features. which can be used to soften up / remove baked on drying oils and used after the animal and vegetable oils, fish oils, tall oils, tug oils etc . It is free from hydrocarbon solvents, Biodegradable minimizes the extreme hazards to personnel in handling materials. RXSOL-16-1502-210 doesn't contain with phosphate, toxicity chloride
- Provides superior,long-lasting cleaning,stain removal & odor control.
- Degrades residual organics (e.g.grease,food spills,urine,etc.) to provide continual deep-cleaning action.
- Prevents the growth of undesirable disease-causing organisms.
- Keeps drain lines,sumps & septic tanks unclogged and free of odor.
Safety and SDS
Read the safety data sheet before handling. Wear suitable gloves and eye protection.
View safety data sheet
| Product Name | RXSOL-16-1502-210 |
| Product Type | Multi Clean TANK WASH (General Cleaning Agent) |
Company Details:
RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA
Stock Point : Mumbai, Kandla, Chennai Ennore, Vizag, Kolkata, Fujairah, Kenya Nairobi, Canada
| Phone | +91 22 65113333 / 5555 / 9999 / 27611360 |
| Fax | +91 22 2781 1318 :::AOH :0091 9821214367 |
| rxsolchemicals@gmail.com |
|
Chemical Name |
Concentration |
CAS Number |
EC Number |
R Phrases* |
Symbols |
|
Alkyl ether sulphate |
1-5 |
3088-31-1 |
221-416-0 |
36/38 |
Xi |
| 2 Butoxy Ethanol | 5 - 10 | 111-76-2 | 1907 | 38 | Xi |
|
Sodium Dodecylbenzene sulfonate |
5-10 |
25155-30-0 |
246-680-4 |
38, 41 |
Xi |
|
Fatty alcoholethoxylates |
1-5 |
34398-01-1 |
500-084-3 |
22,41 |
Xn |
|
Sodium carbonate |
1-5 |
497-19-8 |
207-838-8 |
36 |
Xi |
| Sodium Meta Silicate | 5-10 | 10213-79-3 | 229-912-9 | 36 | Xi |
| Non Ionic Surfactant | 5-10 | 9016-45-9 | 648 | 22,41 | Xi |
*See Section 16
|
Odour |
Odourless |
|
Appearance |
Liquid, pale yellow, soluble in water |
|
Contact with eyes |
Risk of serious damage to eyes (R41) |
|
Contact with skin |
Repeated exposure may cause skin dryness or cracking (R66), Mildly irritating to skin |
|
Inhalation |
Vapours or aerosols may cause irritation of eyes, nose and respiratory tract |
|
Ingestion |
The ingestion of significant quantities may cause gastrointestinal disturbances |
|
Contact with skin |
Remove contaminated clothing immediately and drench affected skin with plenty of water. Then wash with soap and water |
|
Contact with eyes |
If the substance has got into eyes, immediately wash out with plenty of water for at least 15 minutes Seek medical advice |
|
Ingestion |
Never give anything by mouth to an unconscious person Give plenty of water to drink Seek medical advice if necessary |
|
Inhalation |
Vapours or aerosols may cause irritation of eyes, nose and respiratory tract Remove patient to fresh air |
|
General |
In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45) |
- Non-combustible
- Carbon oxides may be formed
- Not flammable. In case of fire use extinguishing media appropriate to surrounding conditions
|
Personal Precautions |
Wear protective clothing as per section 8. |
|
Environmental Precautions |
No special precautions are required for this product. |
|
Immediate Actions |
Shut off the source of leak if safe to do so. |
|
Clean Up Actions |
Absorb spillage in the suitable inert material Flush spill area with copious amounts of water |
|
Special Precautions |
Wear protective clothing as per section 8. |
|
Handling |
The usual precautions for handling chemicals should be observed Eyewash bottles should be available |
|
Storage |
Keep only in the original container in a cool, well-ventilated place (S3/9/49) Protect from frost |
|
Exposure Limits |
There are no recommended or established controls for this product |
|
Exposure controls |
No special ventilation is required unless the product is used in a spray form |
|
Occupational exposure controls |
No respiratory protection is required unless subject to contact with substance mist Wear suitable protective clothing, including eye/face protection and gloves (plastic or rubber are recommended) |
Goggles Respirator
|
Odour |
Odourless |
|
Appearance |
Liquid, pale yellow, soluble in water |
|
pH |
8.5 - 9 at 100 % concentration |
|
Boiling point > |
100 °C at 760 mm /Hg |
|
Vapour pressure |
not known |
|
Freezing point |
< 0 °C at 760 mm/Hg |
|
Completely soluble in water |
|
|
Specific gravity (water=1) |
1.03 |
|
Non-combustible |
|
- This article is considered stable under normal conditions, No hazardous reactions are known if used for its intended purpose
- See Section 5
|
Toxicological information |
No experimental data available |
|
Inhalation |
Vapours or aerosols may cause irritation of eyes, nose and respiratory tract |
|
Contact with skin |
In cases of severe exposure, irritation may develop |
|
Contact with eyes |
Causes irritation Can cause damage to the eyes |
|
Ingestion |
The ingestion of significant quantities may cause gastrointestinal disturbances |
|
Carcinogenicity |
No evidence of carcinogenic effects |
|
Ecotoxicity |
This cleaning agent consists of readily biodegradable surfactants, all of which have only slight or moderate tocixity. |
|
Mobility |
Completely soluble in water |
|
Persistence and Biodegradability |
The components in this product are readily biodegradable. |
|
Bioaccumulation Potential |
Bioaccumulation of the components in this product is insignificant. |
|
Other Adverse Effects |
Presents little or no hazard to the environment |
|
Classification |
EU Waste class |
|
Disposal considerations |
Do not discharge into drains or the environment, dispose to an authorised waste collection point Disposal should be in accordance with local, state or national legislation |
- Not classified as hazardous for transport
|
Risk Phrases |
Risk of serious damage to eyes (R41). |
|
Safety Phrases |
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice (S26) Wear suitable gloves and eye/face protection (S37/39). |
The text of R and S phrase codes used in this safety data sheet:- R22: Harmful if swallowed; R36: Irritating to eyes; R36/38: Irritating to eyes and skin; R38: Irritating to the skin; R41: Risk of serious damage to eyes. The information provided about the product on this Safety Data Sheet has been compiled from knowledge of the individual constituents The data given here is based on current knowledge and experience. This Safety Data Sheet describes the product in terms of safety requirements and does not signify any warranty with regard to the product's properties. The data given here only applies when product used for proper application(s). The product is not sold as suitable for other applications - usage in such may cause risks not mentioned in this sheet. Do not use for other application(s) without seeking advice from the manufacturer.
DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.
Availability
Multiclean supplier for shipping Industries. We are Multi Clean Tank Cleaning detergent supplier in Fujairah, Dubai, Sharjah, Abudhabi, Ajman, Sohar, Muscat Barka Ruwi Ghala Oman and Mumbai, Gandhidham Kandla Mundra, Hazira, JNPT Nhava Seva, Chennai Ennore, Visakhapatnam, Gangavaram, Kolkata Haldia, Paradip, Kenya MOmbasa Nairobi, Uganada, Canada, Sudan, Yemen
