Phosphoric Acid Cleaner Disinfectant Blast
- Part number
- RXSOL-17-1068-025
- Category
- House / HOTEL & CATERING
- Brand
- RXSOL
Overview
Multi-Purpose Cleaner Sanitizer CLEANS, REMOVES MILK STONE. Its MIXING IS EASY SANITIZES. Phosphoric acid is a colourless, odourless phosphorus-containing inorganic acid. Phosphoric acid is a sequestering agent which binds many divalent cations.
Applications
Blast Dairy Cleaner is easily and quickly dispersed in hot or cold water and cleans in water up to 1700 ppm of hardness (as calcium carbonate) to form a completely uniform solution. Blast Dairy Cleaner Dairy Cleaner/Sanitizer when used at a 1:500 aqueous dilution (200ppm active quaternary) may be used on food processing and dairy equipment.
CLEANING BULK MILK TANKS
As soon as possible after milk has been removed from bulk tanks, rinse tank completely with cold water and allow to drain. Place 4 gallons of warm water (120°F) in tank and add 1 ounce (2 tablespoons) Blast Dairy Cleaner to the water in the tank. Scrub tank, mixers and covers and then allow to drain.
HARD WATER TOLERANCE
This product fulfills the criteria of Appendix F of the Grade A Pasteurized Milk Ordinance 1965 recommendation of the U.S. Public Health Service in waters up to 600ppm of hardness calculated as calcium carbonate, when tested by the AOAC Germicidal and Detergent/Sanitizing Official Method. Consult you milk inspector or health officers for recommendations on your local program.
Dosage and directions
SANITIZING PRODUCT DISPENSING EQUIPMENT
Previously cleaned product dispensing equipment should be sanitized by preparing a 200ppm solution of active quaternaries by mixing 1 ounce Blast Cleaner in 4 gallons of water. Run this solution through the equipment for one minute and allow to drain before use. For removable parts, clean and dip in 200ppm solution. Let them air dry. To sanitize immobile items, flood them with a 200ppm active quat by sponging or spraying for at least 60 seconds and let dry. Do not rinse equipment with water after treatment.
Characteristics and notes
KEEP OUT OF REACH OF CHILDREN Corrosive. Causes severe eye and skin damage. Do not get in eyes, on skin or on clothing. Wear goggles or face shield and rubber gloves when handling. Harmful or fatal if swallowed. Avoid contamination of food. Remove and wash contaminated clothing.In case of contact, immediately flush eyes or skin with plenty of water for at least 15 minutes. For eyes, call a physician. Remove and wash contaminated clothing before reuse. If swallowed, drink promptly a large quantity of water. Avoid alcohol. Call a physician immediately.
Safety and SDS
Read the safety data sheet before handling. Wear suitable gloves and eye protection.
View safety data sheet
| Product Name | RXSOL-17-1068 |
| Product Type | Phosphoric Acid Cleaner Disinfectant (Blast) |
Company Details:
RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA
| Phone | +91 22 65113333 / 5555 / 9999 / 27611360 |
| Fax | +91 22 2781 1318 :::AOH :0091 9821214367 |
| rxsolchemicals@gmail.com |
|
Chemical Name |
SARA-III LIST |
CAS Number |
OSHA PEL |
ACGIH |
Carcinogen |
| PHOSPHORIC ACID | Yes | 7664-38-2 | 1mg/m3 | 1mg/m3 | d |
| ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE | No | 68391-01-5 | N/E | N/E | d |
| ALKYL DIMETHYL ETHYL BENZYL AMMONIUM CHLORIDE | No | 68956-79-6 | N/E | N/E | d |
| BUTYL CELLOSOLVE | Yes | 111-76-2 | 25 | 25 | d |
|
Odour |
buytl fragrance |
|
Appearance |
clear, non-viscous, liquid |
|
Contact with eyes |
Liquid can cause eye irritation, severe burns & permanent damage including |
|
Contact with skin |
Liquid can cause burning of skin. Repeated or prolonged contact can cause |
|
Inhalation |
Mist & spray can cause respiratory tract irritation with burning, choking, coughing. High concentrations &/or prolonged contact can cause inflammation & destruction of nasal |
|
Ingestion |
Can cause severe burns of mouth, esophagus and stomach. Nausea, pain and vomiting can occur. |
|
Eye Contact: |
Irrigate with large quantities of water, lifting upper and lower eyelids occasionally. Get medical attention. |
|
Skin Contact: |
Remove contaminated clothing & wash skin with large quantities of water. If irritation persists, get medical attention. |
|
Ingestion |
DO NOT INDUCE VOMITING. Drink 3 to 4 glasses of water. Get immediate medical attention. |
|
Inhalation |
Remove to fresh air. If breathing stops, give artificial respiration. Get immediate medical attention. |
- FLASH POINT AND METHOD USED:-Non-combustible
- EXTINGUISHER MEDIA:-Non-combustible. Use agents as appropriate for materials in surrounding fire.
- SPECIAL FIRE FIGHTING PROCEDURE S : Non-combustible. Use clothng & safety equipment as may be suitable for phosphoric acid
& materials in the surrounding fire.
|
Respiratory Protection ( specify type) : |
Not normally needed at ambient temperatures. Under fire conditions, use approved self-contained breathing apparatus with full face piece |
|
Protective Gloves : |
Neoprene or PVC. |
|
Eye Protection: |
Chemical goggles, face shield where splashing is possible. |
|
Other Protective Clothing & Equipment : |
Safety showers & eyewash stations. Neoprene or PVC rain suit & boots, if needed. |
|
Hygienic WorkPractices : |
Avoid contact wtih skin. Do not eat, drink or smoke in work area. Wash hands after handling. Remove contamianted clothing. |
|
Ventilation Requirements : |
As necessary to maintain air concentrations below 1mg/m3 at all times. Special ventilation is not normally needed. |
|
Steps To Be Taken If Material Is Spilled Or Released: |
Contain spill & prevent run off into ground & surface waters or sewers. Neutralize with soda ash. Recover neutralized products into properly labeled non-leaking containers for proper disposal |
| Waste Disposal Methods: | Dispose of in accordance with all local, state and federal regulations. |
|
Storage |
Store in original shipping containers. Keep closed when not in use. Do not store near strong alkalis or other reactive materials. Shelf life 1 year. Protect from extreme heat and cold. |
| Other Precautios & / or Special Hazar s : | KEEP OUT OF REACH OF CHILDREN |
|
FLASH POINT AND
METHOD USED |
Non-combustible. |
|
EXT INGUISHER MEDIA: |
Non-combustible. Use agents as appropriate for materials in |
|
SPCIAL FIRE FIGHTING PROCEDURES : |
Non-combustible. Use clothng & safety equipment as may be suitable for phosphoric acid & materials in the surrounding fire. |
|
Appearance: |
clear, non-viscous, liquid |
|
Odor |
buytl fragrance. |
|
Boiling Point: |
215ºF |
|
Vapor Pressure: |
N/A |
|
Solubility in Water: |
Miscible |
|
Specific Gravity (H2O=1): |
1.06 |
|
Evaporation Rate |
1.0 |
| Water Reactive: |
None |
- Incompat ibility (Mat. to avoid):Incompatibility (Mat. to avoid): Bases, metals, mercuric sulfate, perchloric acid, carbides,
acetylides, phosphides & silicides.
- Condi t ions to Avoid: None
|
Toxicological information |
No experimental data available. |
|
Inhalation |
Mist & spray can cause respiratory tract irritation with burning, choking, coughing. High concentrations &/or prolonged contact can cause inflammation & destruction of nasal |
|
Contact with skin |
Liquid can cause burning of skin. Repeated or prolonged contact can cause |
|
Contact with eyes |
Liquid can cause eye irritation, severe burns & permanent damage including |
|
CHRONIC EFFECTS: |
Repeated episodes of tissue damage may result in accumulation of scar tissue. |
|
Ingestion |
Can cause severe burns of mouth, esophagus and stomach. Nausea, pain and vomiting can occur. |
| Medical Conditions General ly Ag gravated by Exposure | Contact may further irritate any pre-existing lesions. |
-
DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.
Availability
Phosphoric Acid Cleaner Disinfectant (Blast) manufacturer supplier distributor in Mumbai, Kandla, Kolkata, Vizag, Chennai, India, Fujairah, Dubai UAE, Muscat Oman, Kenya Africa. Get the best quality of Phosphoric Acid Cleaner Disinfectant (Blast) at a competitive price from us. We have ready stock of Phosphoric Acid Cleaner Disinfectant (Blast) in India, UAE Gulf, Oman, Kenya Africa. Contact us for bulk as well as small orders.
